Install the fuel tank sender electrical connector.Ħ. Install the fuel tank pressure sensor electrical connector.ĥ. Install the fuel tank retaining straps.Ĥ. NOTE: Refer to Fastener Notice in Service Precautions.ģ. With the aid of an assistant, raise the fuel tank (1) to body. Install the fuel sender assembly to tank.Ģ. Fuel pipe O-rings for cuts, nicks, swelling or distortion. Clean or replace components/assemblies as required. IMPORTANT: Inspect all connectors for dirt and burrs. Remove the fuel sender assembly from the tank. Remove the fuel sender electrical connector.ġ7. Remove the fuel tank pressure sensor electrical connector.ġ5.
With the aid of an assistant, lower the fuel tank.ġ4. With the aid of an assistant, support fuel tank (1) and disconnect the two fuel tank retaining straps.ġ3. Remove the hoses at tank from filler, vent and vapor pipes.ġ2. Allow exhaust system to rest on rear suspension.ġ1.
Remove the quick connect fittings at the end of the fuel pipe and vapor pipes.ĩ. Disconnect the quick-connect fitting at the fuel filter.ħ. Using compressed air, blow out dirt from the quick-connect fittings at end of the fuel pipes.Ħ. Repeat for the other nylon fuel pipe quick-connect fitting.ĬAUTION: Wear safety glasses when using compressed air in order to prevent eye injury.ĥ. Twist the quick-connect fitting 1/4 turn in each direction to loosen any dirt within fitting. Grasp the nylon fuel pipe quick-connect fitting. Raise the vehicle and suitably support.Ĥ. Refer to Fuel Tank Draining Procedure.ĬAUTION: Refer to Vehicle Lifting Caution in Service Precautions.ģ. I would stick with a factory replacement not a universal a lot less work and you would at least know when the job was done you would haven't to possibly take it apart again.I posted removing the fuel tank and replacing the sending unit.Did you test to see if you had a bad sending unit or are you guessing?Also here is a a/c delco sending unit i found for your car here is the link.Not that hard to change if your used to working on car's.Let me know how it come's out.
0 kommentar(er)
